• PU-Foam

Zwaluw PU-Foam is a 1-component insulation and construction polyurethane foam developed to create a seal between construction parts

Zwaluw PU-Foam cures in response to moisture from the air and the building material


Benefits:

  • High quality professional PU Foam


Limitations:

  • Not suitable for PE, PP, PC, PMMA, PTFE, soft plastics, neoprene and bituminous substrates
  • Not suitable for permanent water load
  • Not suitable for use in cavities with insufficient moisture


Applications:

  • Zwaluw PU-Foam was developed to fill joints around window frames and in construction, partition walls, ceiling and floor joints, surface penetration of pipes and tubes through wall and floors
  • Zwaluw PU-Foam has excellent adhesion to concrete, brick, stone, plaster, wood, metal and many plastics like EPS and XPS, rigid PU foam and uPVC


Directions Of Use:

  • Canister temperature:  +5 to +30 Degree Celsius 
  • Application temperature (applies to environment and substrates) +5 to +35 Degree Celsius
  • Remove cap and screw the straw firmly onto the valve
  • Shake the canister vigorously prior to use at least 20 times
  • To apply foam, turn the canister upside down and press the adaptor
  • Half fill the cavity and, in case of low humidity, lightly spray the foam with water
  • The foam will expand to fill the rest
  • When fixing window frames, use spacers and wedges to hold the fame in place for approximately  24 hours until the foam is fully cured
  • Protect eyes, wear gloves and protective gear
  • Floor-covering and furniture to be covered with paper or plastic foil
  • Joints wider and deeper than 4cm should be filled in multiple layers
  • Wait 15-30 minutes between applications
  • Before each application lightly spray with water
  • Only use in well ventilated areas
  • Store canister upright
  • Pressurized container
  • Protect from sunlight and do not expose to temperatures exceeding +50 Degree Celsius
  • Do not pierce or burn, even after use
  • Contains flammable propellants
  • Do not spray on a naked flame or any incandescent material
  • Keep away from sources of ignition


Surface Preparations and Finishing:

  • Substrates must be clean and free of dust, oil and grease
  • It is important to moisten substrates slightly before use as this improves adhesion and finished cell structure of the foam


Paintability:

  • Can be painted or covered with sealant/plaster when fully cured


Zwaluw PU-Foam is packaged in a aerosol canister of 500ml and 750ml

Zwaluw PU-Foam are available in single units or in boxes of 12 units

MSDS available in documentation tab on this page!

Write a review

Note: HTML is not translated!
    Bad           Good
Captcha

PU-Foam

  • R120.00



Select A Size!


Other Similar Products

Silicone Universal 1001

Silicone Universal 1001

Den Braven Zwal..

R65.00

Allround Sealant

Allround Sealant

Zwaluw Den Brav..

R105.00

Butylene-X

Butylene-X

Zwaluw Den Brav..

R60.00

FP PU Hand Held Foam

FP PU Hand Held Foam

Zwaluw FP PU Ha..

R230.00

Fix-O-Chem

Fix-O-Chem

Zwaluw Fix-O-Ch..

R205.00

Gluescrews SBR

Gluescrews SBR

Zwaluw Gluescre..

R85.00

High Tack

High Tack

Zwaluw Hight Ta..

R135.00

Hybriflex 540

Hybriflex 540

Zwaluw Hybrifle..

R110.00

Mirrorfix-MS

Mirrorfix-MS

Zwaluw Mirrorfi..

R130.00

Silicone NO-MF

Silicone NO-MF

Zwaluw Silicone..

R105.00

Polyflex 422

Polyflex 422

Zwaluw Polyflex..

R100.00

Super Glue 601

Super Glue 601

Zwaluw Super Gl..

R12.00

Gasket Sealant Red

Gasket Sealant Red

Zwaluw Gasket-S..

R170.00

Tectane Polyflex 452

Tectane Polyflex 452

Zwaluw Tectane ..

R110.00

Woodflex Hard

Woodflex Hard

Zwaluw Woodflex..

R75.00

Tags: PU-Foam

New Arrivals

Now Trending
New Release!
HELICOIL - Free Running Inserts - Green
New Release!
HELICOIL Set (Eco Thread Repair Kit)
New Release!
Pratlok Anaerobic Threadlocker
SALE !
New Release!
Pratley High Performance Epoxy Adhesives
New Release!
Keys (Pre-Cut) - Y - Series
New Release!
Pratley Epoxy Putty

This Weeks Best Selling Products Are...

Top Seller
Hex Nuts Black M12 - M30 (Sold Each)
Top Seller
Hi-Tensile Bolt M16 (Sold Per Each)
Top Seller
Coupling Nuts Zinc M12 - M20 (Sold Per Each)
Top Seller
SALE !
Makita GA4530 Angle Grinder

Makita GA4530 Angle Grinder

R1,299.00 R1,400.00

Top Seller
Drywall Screws Fine Thread (Sold Per 100)
Top Seller
Cap Screw M 5 (Sold Per 100)
Top Seller
Hi-Tensile Bolt M12 (Sold Per Each)
Top Seller
Cap Screw M 8 (Sold Per 100)